Air Duct Inspection
We start by checking your whole duct system. We look for leaks, tears, crushed sections, loose connections, poor insulation, and ducts that are the wrong size. Then we show you what we found and explain your options.
Inspect · Repair · Seal · Replace
Air Duct Replacement in Pflugerville, TX Get the Cool Air You Pay For
Are some rooms always hot? Are your power bills going up? Does your AC run all day but never quite keep up? Your air ducts may be the problem. AC Repair Pflugerville has repaired and replaced air ducts in Pflugerville homes for more than 13 years. We find leaks, fix damaged ducts, and replace old ductwork so your AC can cool every room the way it should.
13+ yearsof duct repair and replacement in Pflugerville
Full duct inspection before we recommend anything
Repairsealing, and full replacement
Licensed and insured techs
130°F+summer attic heat in Pflugerville
Attic heat
Why Air Ducts Matter So Much in Pflugerville
Your air ducts carry cool air from your AC to every room in your home. If the ducts leak, a big part of that air never reaches you. Instead, it escapes into your attic.
In Pflugerville, this problem is often worse than in other places:
- Most ducts are in the attic. In summer, Pflugerville attics can get over 130°F. Leaky ducts lose cool air into that heat, and hot attic air gets pulled back into your home.
- Heat breaks ducts down. Years of extreme attic heat can dry out duct tape, crack insulation, and make flex duct brittle.
- Many homes are 15 to 30 years old. Ducts installed when the home was built may now be worn out, crushed, or falling apart.
- Pests and storage. Rodents can chew ducts, and boxes or work in the attic can crush or disconnect them.
Leaky ducts can waste a large share of the air your AC makes. That means higher bills, hot rooms, and an AC that works harder and wears out sooner.
Warning signs
Signs You Need Air Duct Repair or Replacement
- Some rooms are always hotter or colder than others
- Your power bills keep going up without a clear reason
- Weak airflow from some vents
- Your AC runs nonstop but the house never gets cool enough
- Lots of dust in your home, even after cleaning
- Musty smells coming from the vents
- Your ducts are 15 to 25+ years old
- You can see damage in the attic: torn, crushed, sagging, or disconnected ducts
- Whistling or rattling sounds from the vents or ceiling
- You recently replaced your AC but still have hot rooms
What we do
Our Air Duct Services
Air Duct Repair
If only part of your ductwork is damaged, we repair it. We reconnect loose ducts, replace damaged sections, fix crushed lines, and secure ducts so they stay in place.
Duct Sealing
Small leaks at joints and connections add up. We seal leaks with proper duct mastic or approved tape, not regular duct tape, which fails fast in attic heat.
Full Ductwork Replacement
When your ducts are old, badly damaged, or poorly designed, replacing the whole system is often the best fix. We remove the old ducts and install new, properly sized and insulated ductwork that is sealed tight.
Duct Redesign for Hot Rooms
Some hot rooms are not caused by leaks. They are caused by ducts that were too small or poorly planned from the start. We can add returns, resize ducts, or add new runs to balance airflow across your home.
Honest advice
Repair or Replace Your Air Ducts?
RepairRepair or seal is usually enough when...
- Ducts are under 15 years old
- Damage is in a few spots
- Insulation is still in good shape
- Airflow is mostly even
- Ducts are the right size
ReplaceFull replacement may be better when...
- Ducts are 20 to 25+ years old
- Damage is spread across the system
- Insulation is cracked or falling apart
- Many rooms have airflow problems
- Ducts were too small or poorly designed
We will show you what we find in your attic, with photos if you like, and give you an honest recommendation. If a repair will do the job, we will tell you.Call Now
7 steps
Our Duct Replacement Process
Most duct replacements in Pflugerville homes are done in 1 to 2 days.
- 01
Call Us
Tell us about hot rooms, high bills, or other problems you have noticed.
- 02
Inspection
We check your full duct system, airflow at each vent, and your AC.
- 03
Clear Plan and Price
We explain what needs to be done and give you a written price.
- 04
Removal
We carefully remove old ducts and haul them away.
- 05
New Ductwork
We install properly sized, insulated ducts with tight, sealed connections.
- 06
Testing
We check airflow at the vents to make sure every room is getting the air it should.
- 07
Cleanup
We protect your home during the work and clean up when we are done.
The payoff
Benefits of New or Repaired Air Ducts
01
More even temperatures in every room
02
Lower power bills, because less cool air is lost
03
Less strain on your AC, so it lasts longer
04
Less dust pulled in from the attic
05
Better indoor air with fewer musty smells
06
Better results from a new AC.A new AC cannot work well with old, leaky ducts.
New AC? Check your ducts too. Many homeowners replace their AC but keep their old ducts. If those ducts leak or are the wrong size, the new AC cannot do its job, and hot rooms stay hot. When you replace your AC, it is a good time to check your ducts too.Learn more about AC Installation & Replacement
Why Choose Us for Air Duct Replacement
13+ Years in Pflugerville
We have worked in Pflugerville attics for more than 13 years. We know how local homes are built and how Texas heat affects ductwork.
We Show You the Problem
We explain what we find and can show you photos from your attic, so you understand exactly what needs to be done.
Done Right, Not Fast
We use proper materials, correct sizing, and sealed connections, so your new ducts last.
Honest Advice
If sealing or a small repair will fix your problem, we will not sell you a full replacement.
Clear Prices
You get a written price before any work starts.
Service areas
Service Areas
We provide air duct repair and replacement in Pflugerville (78660 and 78691), Round Rock, Hutto, Georgetown, Wells Branch, Manor, and North Austin.
Questions & answers
Air Duct Replacement Pflugerville FAQs
How long do air ducts last?
Most air ducts last about 15 to 25 years. In hot Pflugerville attics, flex ducts and insulation can wear out sooner.
How do I know if my ducts are leaking?
Common signs are hot rooms, weak airflow, high power bills, and extra dust. A duct inspection is the best way to know for sure.
Can leaky ducts make my power bill higher?
Yes. When ducts leak, cool air escapes into the attic and your AC has to run longer to cool your home.
How much does air duct replacement cost in Pflugerville?
It depends on the size of your home, how many vents you have, and attic access. After we inspect your system, we give you a written price.
How long does duct replacement take?
Most homes take about 1 to 2 days.
Should I replace my ducts when I replace my AC?
Not always, but it is a great time to check them. Old or leaky ducts can stop a new AC from working well.
Can you fix just one hot room?
Often, yes. We can check the duct to that room, fix leaks, and resize or add a duct run if needed.
Stop paying to cool your attic
Fix Hot Rooms and High Bills in Pflugerville
Stop paying to cool your attic. Our local team has repaired and replaced air ducts in Pflugerville for over 13 years, and we are ready to help. Call AC Repair Pflugerville at (512) 737-6599.